PRODUCTS

1500 KVA (with PCC)

SPECIFICATION FOR AUTO SYNCHRONISING AND AUTO LOAD SHARING

CONTROL PANEL
FOR 1500kVA DG SET CONTROLLED BY PCC3100

Cubicle type, floor mounting control panel with hinged doors, un-drilled bottom gland plate, AL. Bus Bar and accommodating the following:

SWITCH GEARS:

• 2500A, 3 Pole EDO ACB with overload relay & short circuit protection.
• 450A, 3 Pole Neutral contactor required for synchronizing operation.

ADDITIONAL FEATURES:

Metering:

• » Combined Meter for Voltage / Ampere / Frequency
• » Combined Meter for kW / Power Factor / kVA
• » Electronic kWH Meter (Counter Display)
• » Current Transformers

Relay:

• » Earth Fault Relay (Electronic type)

Indications (LED):

• » DG ON , Load on DG, Mains ON

Push Buttons

• » Fault ACCEPT / RESET

BATTERY CHARGER:(Applicable for AMF Panel only)

• SMPS Based Unit with inbuilt Auto/Manual & Float/Boost Facility
• DC Voltmeter & Ammeter (Separate)
• Battery Charger ON (Indication LED)


• DOL Starter with Auto Intermittent System for Lub Oil Priming Pump

Details of PCC 3100 ( Separate Panel Located near the Engine )

Measurement :-

For Alternator

• » Voltage 3ph. L-L & L-N, Frequency, Current 3ph, Total KVA, PF, KW,    KVA, KVAR & KWH

For Engine

• » Oil press, Water temp, Engine speed, Hours run, No. of starts

Protection

For Alternator

• » U/V,O/V, U/F,O/F, O/C & Short circuit Overload, Over speed, Reverse    power,

For Engine

• » LLOP, Low & High coolant temp, Low coolant level, Low & High Battery    voltage, Over crank, Fail to crank,

Integrated Automation function / sequences through PCC 3100

Integrated Automation functions/sequences, through GCU

• » Auto start & stop
• » Auto Synchronising
• » Auto Load Sharing (KW & KVAr )

PLHO / 0712/RKS/ASN